Gale Banks Engineering - Diesel Performance Specialists F250 User Manual download pdf (Page 3)

emove Stock Components

1. Remove the (+) and (-) battery

cables from both the drivers and

assenger side batteries.

2. Undo the two toggle clamps at

the rear of the air box assembly.

3. Disengage the two tabs on the

lower backside of the air box

assembly from the slots on the rear

cover.

4. Remove the air box assembly and

air box front cover from the vehicle.

5. For 2005-06 4-wheel drive

equipped vehicles only:

Remove the

electronics module near the driver

side battery shown in

Figure 1. The

retaining tab for the module can be

pried back with a flat blade

screwdriver as shown in the figure.

After the tab is depressed, the

module can easily be pulled away

from it's mounting bracket.

6. Remove driver’s side plastic

battery cover. There are tabs at the

front and back of the cover that need

to be depressed to remove the cover,

as shown in

Figure 2. Note: Be

careful not to break the plastic box,

as it will be re-installed later.

7. Remove the driver’s side battery

hold down clamp (8mm socket).

8. Remove the driver’s side battery.

WARNING: When lifting a battery,

excessive pressure on the end

walls could cause acid to spew

through the vent caps, resulting in

personal injury. Lift with a battery

carrier or with hands on opposite

corners. Failure to follow these

instructions may result in

personal injury.

9. Remove the wire harness plastic

retaining clip on the back of the

plastic battery box.

10. Remove the plastic battery box

[(4x) 13mm socket].

For 2005-06

4-wheel drive equipped vehicles only:

A small bracket used to mount an

electronic module will also be

removed with the plastic battery tr

ay.

96782 v.2.0 3

Figure 2

Figure 1. Electronic module near the driver side battery on 2005-06 4-wheel

drive equipped vehicles

1 2 3 4 5 6 7 8 ... 11 12

Comments to this Manuals

No comments

Gale Banks Engineering - Diesel Performance Specialists F250 User Manual Page 3

Comments to this Manuals